Fractionation of Hevea brasiliensis latex by centrifugation: (ii) a mean to locate the drivers of natural rubber unique structure and properties?

Chaiyut Jutaporn, Liengprayoon Siriluck, Bottier Céline, Lecomte Sophie, Peruch Frédéric, Rattanaporn Kittipong, Granet Françoise, Char Christine, Bonfils Frédéric, Vaysse Laurent. 2017. Fractionation of Hevea brasiliensis latex by centrifugation: (ii) a mean to locate the drivers of natural rubber unique structure and properties?. . IRRDB. Jakarta : IRRDB, 12 p. International Rubber Conference & IRRDB Annual Meeting, Jakarta, Indonésie, 18 Octobre 2017/20 Octobre 2017.

Résumé : The biochemical composition of Fresh Hevea latex fraction s (cream, skim, C- serum, lutoids) was comprehensively described in the first part of this publication. The fractions obtained from the same latex were remixed. The rebuilt latex was used to prepare ADS (Air Dried Sheet) rubber sheets. The possible quantitative effects of the component s of each fraction on the structure and properties of the obtained rubber ADS samples were studied. This protocol was performed on lattices harvested from 2 clones (RRIM600 and PB2 35). The obtained rubber samples made from latex containing various proportions of serum and/or lutoid fractions, were submitted to a panel of analytical characterizations: lipid extract, mineral composition, mesostructure (SEC-MALS), Initial Plasticity P 0, Plasticity Retention Index (PRI), and Accelerated Storage Hardening Test (ASHT). Moreover, non-accelerated 2-month storage in controlled conditions was also studied. While the proportion of serum and/or lutoid did not influence much the structure and properties of freshly obtained dry ADS rubber, an important effect of their presence was evidenced on the change of structure and properties during storage. For example, ADS rubber samples made from lutoid- and serum-deprived latex were those that showed the lowest AP (ASHT) and the lowest Agel and APo after 2-month storage. In addition, clonal differences in terms of lipid extract, rubber structure and properties were underlined: when compared to RRIM600 rubber, PB235 rubber showed higher lipid content, Po, Mn, Mw and lower mineral content, AP (ASHT) and APo (2-month non accelerated storage).

Classification Agris : Q60 - Traitement des produits agricoles non alimentaires
F60 - Physiologie et biochimie végétale

Auteurs et affiliations

• Chaiyut Jutaporn, CIRAD-PERSYST-UMR IATE (FRA)
• Liengprayoon Siriluck, Kasetsart University (THA)
• Bottier Céline, CIRAD-PERSYST-UMR IATE (THA) ORCID: 0000-0002-5318-4275
• Lecomte Sophie, CNRS (FRA)
• Peruch Frédéric, CNRS (FRA)
• Rattanaporn Kittipong, KURDI (THA)
• Granet Françoise, Michelin (FRA)
• Char Christine, CIRAD-PERSYST-UMR IATE (FRA)
• Bonfils Frédéric, CIRAD-PERSYST-UMR IATE (FRA) ORCID: 0000-0001-7016-4770
• Vaysse Laurent, CIRAD-PERSYST-UMR IATE (THA) ORCID: 0000-0003-3264-6116

Source : Cirad-Agritrop (https://agritrop.cirad.fr/586131/)

Métriques

[ Page générée et mise en cache le 2024-11-13 ]